Material Safety Data Sheet
Complies with Hazard Communication Standard 29 CFR
1910.1200
Printer Friendly Copy
|
Manufacturer |
HARD BALL Chemical Company |
|
Phone |
(888) 261-3103 |
|
708 Pulaski Street |
|
Fax |
(217) 735-4626 |
|
Lincoln, IL 62656 |
|
Emergency Phone |
(888) 261-3103 |
|
|
|
Chemtrec Phone |
(800) 424-9300 |
|
Date Prepared |
January 10, 2000 |
|
Revised |
|
|
MSDS Number |
505 |
Section I – Product Identification
|
Product Name: |
Soil-Blocker Water Based Fabric Protector |
|
Chemical Name: |
Mixture |
|
NFPA Hazard Classification: |
Health – 1, Flammability – 0, Reactivity
– 0 |
Section II – Hazardous Ingredients/Identity
Information
The specific chemical identities of the ingredients
are considered to be trade secrets and are withheld in accordance with
the provisions of 1910.1200 of Title 29 of the Code of Federal
Regulations.
Mixture is a mild eye and skin irritant. Mixture is not considered
a carcinogen by IARC or NTP. All components are registered with
TSCA. This mixture is reasonably believed not to contain any toxic
chemicals in quantities subject to reporting requirements of SARA (1986,
Section 313, Title III) and 40 CFR 372. Mixture is a water based
polymer solution.
Section III – Physical/Chemical Characteristics
|
Initial Boiling Point |
212°C |
|
Specific Gravity (H2O=1) |
~1 |
|
Vapor Pressure (mm Hg at 68° F) |
< 1 |
|
Evaporation Rate (Butyl Acetate=1) |
< 1 |
|
Percent Volatile by Volume |
~3% |
|
Vapor Density (Air=1) |
> 1 |
|
Solubility in Water |
Miscible |
|
Appearance & Odor |
Milky white, slight acrylic odor |
Section IV – Fire and Explosion Hazard Data
|
Flash Point (TCC) |
None |
|
Autoignition& |
Not Determined |
|
Flammability Limits in Air |
Lower Explosive Limit: ND, Upper Explosive
Limit: ND |
|
Extinguishing Media |
Water, Foam, CO2, Dry Chemical |
|
Special Fire Fighting Procedures |
Use self-contained breathing apparatus |
|
Unusual Fire and Explosion Hazards |
None known. Material is non-flammable and
non-combustible |
Section V – Reactivity Data
|
Stability |
Stable |
|
Conditions to Avoid |
None known |
|
Incompatibility (Materials to Avoid) |
None known |
|
Hazardous Decomposition or Byproducts |
If burned, normal combustion products are
Carbon Dioxide & Carbon Monoxide |
|
Hazardous Polymerization |
Will not occur |
Section VI – Health Hazard Data & Primary
Routes of Exposure
Effects of Overexposure:
|
Eyes |
Mildly Irritating |
|
Skin |
Mildly irritating with prolonged exposure. |
|
Inhalation |
Over inhalation may cause symptoms such as
coughing. May aggravate pre-existing lung disorders. |
|
Ingestion |
Harmful if swallowed. Obtain medical
care. |
Emergency and First Aid Procedures:
|
Eyes |
Flush with water for 15 minutes and get medical
attention if irritation persists. Remove contact lens if worn. |
|
Skin |
Immediately flush skin with soap and plenty of
water. Remove contaminated clothing. |
|
Inhalation |
Remove to area of fresh air. Get medical
attention if effects are persistent. |
|
Ingestion |
Seek immediate medical care. Drink a quart or
more of water and induce vomiting. Never give anything by
mouth to an unconscious person. |
Section VII – Precautions for Safe Handling and Use
Steps to be Taken in Case Material is Released or
Spilled:
|
Small |
Confine and isolate spill. Pick up spilled
material with absorbants. |
|
Large |
Confine and isolate spill. Pick up spilled
materials with absorbants or pump. Store used absorbants in
approved covered waste can or soak with water before disposal. |
Waste Disposal Method:
|
Small |
Check federal, state, and local regulations. |
|
Large |
Check federal, state, and local regulations. |
Handling & Storing:
Store in cool dry place in sealed containers. Keep
out of the reach of children.
Other Precautions:
Do not get in eyes, on skin or on clothing. Remove
and wash contaminated clothing before reuse. Do not take internally.
Section VIII – Control Measures
|
Respiratory Protection |
Not required if ventilation is adequate.
Use only in well-ventilated area. |
|
Ventilation |
Mechanical (general) ventilation is usually
adequate. |
|
Protective Gloves |
Neoprene. |
|
Eye Protection |
Safety goggles. |
|
Other Protective Clothing or Equip |
Eye bath, safety shower. Safety glasses
should be worn. |
|
Work/Hygienic Practices |
Practice good personal hygiene. Wash after
handling. Avoid contact with skin and eyes. Avoid breathing
vapors. Use with adequate ventilation. Keep container closed
and away from heat and flames. |
Section IX – Transportation Data
|
Proper Shipping Name |
Non-hazardous Liquid, N.O.I. |
|
DOT Identification Number |
None |
|
DOT Hazard Class |
Not Regulated |
The information and recommendations set forth herein
are presented in good faith and believed to be correct and reliable.
HARD BALL Chemical Co. makes no representation as to the completeness or
accuracy thereof and supplies information upon the condition that the
persons receiving same will make their own determination as to its
suitability for their purpose prior to use.
